Product ID:EP-W TONER
MSDS Date:01/31/1987
FSC:6850
NIIN:00N084934
MSDS Number: CGVGH

NASHUA

44 FRANKLIN ST
NASHUA, NH 03061
US

Emergency Phone: 303-623-5716;800-424-9300(CHEMTREC)

Info Phone: 603-880-2323

Cage: JO663

NASHUA CORP OFFICE PRODUCTS DIV.

NASHUA, NH 03060 US

Telephone: 603-880-2323

Cage: 34936

STYRENE/ACRYLATE POLYMER

CAS: 25036-15-2

Fraction By Weight: 40-55%

OSHA PEL N/K

ACGIH TLV: N/K

MAGNETITE

CAS: 1309-38-2

RTECS: OM4800000

Fraction By Weight: 40-50%

OSHA PEL N/K

ACGIH TLV: N/K

PROPENE POLYMERS; (POLYOLEFIN)

CAS: 9003-07-0

RTECS: TR5000000

Fraction By Weight: 1-5%

OSHA PEL N/K

ACGIH TLV: N/K

AMORPHOUS SILICA

CAS: 57762-90-7

Fraction By Weight: 0.5-3.0%

OSHA PEL 5 MG/M3 (MFR)

ACGIH TLV: 10 MG/M3 (MFR)

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: MAY CAUSE IRRIT. SKIN:
MAY CAUSE IRRIT. RPTD CONT MAY CAUSE IRRIT; MAY CAUSE ALLERGIC SKIN
RXN. INHAL: DUST COULD CAUSE RESP IRRIT ABOVE TLV, BUT CONSIDERED
AT LOW HAZ. INGEST: MAY CAUSE IRRIT OF MUC MEMBS/DIGESTIVE TRACT.
CHRONIC: A COMPURERIZED LITERATURE SEARCH OF NATL DATABASES DID
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: NOT YIELD ANY CHRONIC EFTS ASSOC
W/THESE MATLS. TOX INFO: TOX PROPERTIES OF THIS SUBSTANCE HAVE NOT
BEEN FULLY INVESTIGATED. RPTS BY XEROX CORPORATION ON SIMILAR
PRODS, INDICATE THAT THIS PR OD IS PRACTICALLY NON-TOXIC.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:EYES: IMMEDIATELY FLUSH WITH PLENTY OF RUNNING WATER FOT AT
LEAST 15 MINUTES. OBTAIN MEDICAL ATTENTION. SKIN: FLUSH AFFECTED
AREAS PROMPTLY WITH WATER FOR 15 MINUTES. REMOVE CONTAMINATED
CLOTHING. IN CASE OF CONTINUED IRRITATION CONSULT MD. INHALATION:
FOR OVEREXPOSURE, REMOVE TO FRESH AIR. INGESTION: OBTAIN IMMEDIATE
MEDICAL ATTENTION.

Extinguishing Media:WATER SPRAY, DRY CHEMICAL, CARBON DIOXIDE OR FOAM.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . CONTAINERS SHOULD BE KEPT COOL WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:TONER, LIKE MOST ORGANIC MATLS IN POWDER
FORM, WHEN DISPERSED IN AIR, CAN FORM EXPLO MIXTURES THAT CAN
PRODUCE TOXIC FUMES SUCH AS CARBON MONOXIDE & DIOXIDE.

Spill Release Procedures:REVIEW FIRST AID & CONTROL MEASURES SECTIONS
BEFORE PROCEEDING W/CLEAN UP. CUT OFF ALL SOURCES OF IGNIT. SWEEP
UP/VACUUM SPILLED TONER & CAREFULLY TRANSFER INTO SEALABLE CONTR,
SWEEP SLOWLY TO MIN GEN ERATION OF DUST DURING CLEAN-UP. (SUP DAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:AVOID EYE AND SKIN CONTACT, AND STORE
IN WELL-VENTILATED AREA. KEEP CONTAINER TIGHTLY CLOSED AND KEEP
AWAY FROM HEAT, SPARKS AND OPEN FLAME.
Other Precautions:DO NOT STORE WITH INCOMPATIBLE MATERIALS. DO NOT
STORE OR CONSUME FOOD, DRINK OR TOBACCO IN AREA WHERE THEY MAY
BECOME CONTAMINATED WITH THIS MATERIAL.

Respiratory Protection:USE NIOSH CERTIFIED DUST MASK IF DUST IS
PRESENT. BE SURE TO MAINTAIN NORMAL ROOM VENTILATION (10 CHANGES OF
AIR PER HOUR).
Ventilation:ROOM VENT IS SUFFICIENT. AVOID USE OF PROD IN UNVENTILATED
AREAS. ALWAYS CTL AIRBORNE LEVELS BELOW EXPOS GUIDELINES.
Protective Gloves:CHEMICAL RESISTANT GLOVES.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:ANSI APPROVED EMERGENCY EYEWASH AND DELUGE
SHOWER . APRONS. DISPOSABLE COVERALLS ARE OPTIONAL.
Work Hygienic Practices:DISCARD DISPOSABLE COVERALLS AFTER USE.
Supplemental Safety and Health
SPILL PROC: IF A VACUUM IS USED, MOTOR MUST BE RATED AS DUST TIGHT. A
CONDUCTIVE HOSE BOUNDED TO MACHINE SHOULD BE USED TO REDUCE STATIC
BUILD-UP. RESIDUE CAN BE REMOVED W/SOAP & COLD WATER. GARMENTS MAY
BE WASHED/DRY CLEANED, AFTER REMOVAL OF LOOSE TONER. WASTE DISP
METH: DISPOSE OF I/A/W LOC, STATE & FED REGS .

Spec Gravity:1.0-3.0(H*2O=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:FINE BLACK POWDER WITH SLIGHT ODOR

Stability Indicator/Materials to Avoid:YES
AVOID STRONG OXIDIZERS.
Stability Condition to Avoid:FLAME OR EXCESSIVE HEAT.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE.

Waste Disposal Methods:ACCORDING TO FED REG 40 CFR 261, THIS MATL IS
NOT HAZ WASTE WHEN DISCARDED. HOWEVER, STATE & LOC REQS MAY BE MORE
RESTRICTIVE. THEREFORE, CONSULTATION W/PROPER STATE & LOC AUTH IS
ADVISED. INCIN IS RE C & ONLY IN CLSD CONTR. (SUP DAT)

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.